NY salt miners rescued after frigid night in stuck elevator

  • The fourth group of workers emerge from an elevator Thursday, Jan. 7, 2016, after they were stuck overnight in a shaft at the Cayuga Salt Mine in Lansing, N.Y. Cargill Inc. spokesman Mark Klein said all 17 miners have been rescued. (Simon Wheeler/The Ithaca Journal via AP, Pool)

    The fourth group of workers emerge from an elevator Thursday, Jan. 7, 2016, after they were stuck overnight in a shaft at the Cayuga Salt Mine in Lansing, N.Y. Cargill Inc. spokesman Mark Klein said all 17 miners have been rescued. (Simon Wheeler/The Ithaca Journal via AP, Pool) Associated Press

  • The fourth group of workers emerge from an elevator Thursday, Jan. 7, 2016, after they were stuck overnight in a shaft at the Cayuga Salt Mine in Lansing, N.Y. Cargill Inc. spokesman Mark Klein said all 17 miners have been rescued. (Simon Wheeler/The Ithaca Journal via AP, Pool)

    The fourth group of workers emerge from an elevator Thursday, Jan. 7, 2016, after they were stuck overnight in a shaft at the Cayuga Salt Mine in Lansing, N.Y. Cargill Inc. spokesman Mark Klein said all 17 miners have been rescued. (Simon Wheeler/The Ithaca Journal via AP, Pool) Associated Press

  • The last of 17 Cargill salt miners emerge Thursday, Jan. 7, 2016, after being rescued from an elevator stuck 900 feet below the surface at the Cayuga Salt Mine, in Lansing, N.Y. A rescue cage was lowered from a crane to bring them up four at a time. (Simon Wheeler/The Ithaca Journal via AP, Pool)

    The last of 17 Cargill salt miners emerge Thursday, Jan. 7, 2016, after being rescued from an elevator stuck 900 feet below the surface at the Cayuga Salt Mine, in Lansing, N.Y. A rescue cage was lowered from a crane to bring them up four at a time. (Simon Wheeler/The Ithaca Journal via AP, Pool) Associated Press

  • This photo provided by the Ithaca Fire Department shows a crane that will assist the rescue of seventeen miners stuck in an elevator underground at the Cargill Salt Mine in Lansing, N.Y., on Thursday, Jan. 7, 2016.   Tompkins County Emergency Management officials say the miners have been trapped since late Wednesday night at the mine, about 40 miles outside Syracuse, and are not in any danger.  (Ithaca Fire Department via AP)

    This photo provided by the Ithaca Fire Department shows a crane that will assist the rescue of seventeen miners stuck in an elevator underground at the Cargill Salt Mine in Lansing, N.Y., on Thursday, Jan. 7, 2016. Tompkins County Emergency Management officials say the miners have been trapped since late Wednesday night at the mine, about 40 miles outside Syracuse, and are not in any danger. (Ithaca Fire Department via AP) Associated Press

  • A truck sits at what would normally be a busy truck staging area at the Cargill salt mine, early Thursday, Jan. 7, 2016, in Lansing N.Y. Emergency crews rescued four of 17 miners early Thursday who were stuck for hours in an elevator 900 feet underground at the salt mine that's the deepest in the Western Hemisphere, officials said. (Simon Wheeler/The Ithaca Journal via AP) NO SALES; MANDATORY CREDIT

    A truck sits at what would normally be a busy truck staging area at the Cargill salt mine, early Thursday, Jan. 7, 2016, in Lansing N.Y. Emergency crews rescued four of 17 miners early Thursday who were stuck for hours in an elevator 900 feet underground at the salt mine that's the deepest in the Western Hemisphere, officials said. (Simon Wheeler/The Ithaca Journal via AP) NO SALES; MANDATORY CREDIT Associated Press

  • Cargill Mine Manager Shawn Wilczynski, right, speaks during an early morning press conference at the Lansing Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours.

    Cargill Mine Manager Shawn Wilczynski, right, speaks during an early morning press conference at the Lansing Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours. Associated Press

  • Cargill Mine Manager Shawn Wilczynski, right, speaks during an early morning press conference at the Lansing Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours.

    Cargill Mine Manager Shawn Wilczynski, right, speaks during an early morning press conference at the Lansing Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours. Associated Press

  • Authorities guard the road to the Cargill salt mine during the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours.

    Authorities guard the road to the Cargill salt mine during the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours. Associated Press

  • Cargill Mine Manger Shawn Wilczynski, center, speaks to the assembled media Thursday, Jan. 7, 2016, at the Lansing, NY Volunteer Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours.  (Simon Wheeler/The Journal via AP)  NO SALES; MANDATORY CREDIT

    Cargill Mine Manger Shawn Wilczynski, center, speaks to the assembled media Thursday, Jan. 7, 2016, at the Lansing, NY Volunteer Fire Department after the rescue of 17 mine staff in Lansing, NY, Thursday, Jan. 7, 2016. The rescued miners were stuck in an elevator 900 feet below the ground for roughly 10 hours. (Simon Wheeler/The Journal via AP) NO SALES; MANDATORY CREDIT Associated Press

 
 
Updated 1/7/2016 4:51 PM

LANSING, N.Y. -- Seventeen miners spent a frigid night in a broken-down elevator in America's deepest salt mine, huddling with heat packs and blankets before being rescued early Thursday, a mishap that highlighted the sometimes-risky work of churning out the road salt that keeps traffic moving on ice and snow.

The workers were descending to start their shifts around 10 p.m. Wednesday when the roughly 5-by-6-foot car abruptly stopped about 90 stories below ground in the Cayuga salt mine while heading to a floor nearly deep enough to fit two Empire State Buildings stacked atop one another.

by signing up you agree to our terms of service
                                                                                                                                                                                                                       
 

The miners would spend the next 10 hours stuck in a shaft that's also an air intake, with night air less than 20 degrees rushing in as they tried to stay warm with heat pads, blankets and containers of coffee that were lowered down, officials said. Ultimately, a crane was brought in from 30 miles away to pull the miners to safety in a cage-like basket, a few at a time, as those gathered up top cheered.

"Their spirits are tremendous. I'm inspired by them, to be quite honest with you," mine manager Shawn Wilczynski said. "The first four that came out of the mine waited until the last two came out."

The rescued miners, who ranged in age from 20 to 60, were checked out and found to be uninjured, and some colleagues who had already descended into the 2,300-foot-deep mine when the lift got stuck emerged safely via another route.

While authorities and mine owner Cargill Inc. were investigating what caused the problem, a spokesman for the Minneapolis-based company said it appeared that the beam that keeps the elevator's car aligned in the shaft was bent or broken.

                                                                                                                                                                                                                       
 

The malfunction came five days after a circuit breaker problem briefly knocked the lift out of service during a test trip with no one underground, according to federal Mine Safety and Health Administration records. And despite a deadly accident in 2010, mine agency official Neal Merrifield said the mine has a good safety record with a lower rate of violations and accidents than similar facilities.

While it's not uncommon for mine lifts to get stuck, the problems rarely last as long or strand so many people as happened Thursday, Merrifield said. But he said overloading wasn't a concern.

The mine taps into a rock salt formation under a swath of upstate New York. With about 200 workers, the mine is one of the few heavy industries in Lansing, a mostly rural town of about 11,000 residents who often commute to jobs at nearby Cornell University and Ithaca College.

The mine processes about 2 million tons of road salt per year, making it one of the nation's biggest producers. The U.S. is second only to China as a source of all types of salt, and more than 40 percent of it goes to melting ice on roadways, the U.S. Geological Survey says.

                                                                                                                                                                                                                       
 

At the mine, vertical shafts allow access to the deposits, and workers remove it using a room-and-pillar approach: blasting to loosen the salt, while leaving pillars of salt in place to support the overhead layers. Then vehicles scoop and haul the blasted salt to a miles-long system of conveyor belts.

The miners work in a ghostly world of tunnels and caverns coated in white. An Ithaca Journal reporter who visited the mine in 2002 described "chunks of salt the size of computer monitors and others the size of footballs" and a taste of salt in the air.

In general, salt mining is considered less dangerous than underground mining for combustible coal. But salt mines have had problems, including a massive collapse of a salt mine near Rochester in 1994. No one was injured, but aquifer water flowed into the mine, opening huge sinkholes above, causing a bridge foundation to crumble and sucking wells dry.

And in 2010, a 150-ton aboveground salt bin collapsed onto a truck at the Cayuga mine, killing the driver and injuring another man. Federal regulators found the management hadn't gotten adequate inspections.

After Thursday's rescue, Cargill made counselors available for families of the miners. And at the nearby Crossroads restaurant, co-owner John Dietershagen was offering free food Thursday to them and their rescuers.

"Lansing is a very tight-knit community," he said. "We all support each other."

___

Peltz reported from New York. Associated Press writers Chris Carola and Mary Esch in Albany and Carolyn Thompson in Buffalo contributed to this report.

___

This story has been corrected to show the miners ranged in age from 20 to 60, not 20 to 40.

0 Comments
                                                                                                                                                                                                                       
 
Article Comments ()
Guidelines: Keep it civil and on topic; no profanity, vulgarity, slurs or personal attacks. People who harass others or joke about tragedies will be blocked. If a comment violates these standards or our terms of service, click the X in the upper right corner of the comment box. To find our more, read our FAQ.